Kia Optima: Adjustment
Inspect Glass Alignment
| 1. |
Check for abnormal noise or bending
during operation. |
| 2. |
With the sunroof fully closed,
check for water leakage. |
| 3. |
The roof panel (A) should be
even with the movable glass (B) weatherstrip, to within the standard value
"E" all the way around. If not, make the following adjustment.
Tightening torque :Standard
value "E" [mm(in.)]
(1) Front edge : 1.2 mm (0.0472 in.)(2) Rear edge : 1.0 mm (0.0394
in.)
|
|
| 4. |
If the position is not as specified,
lightly loosen the glass adjusting screws (A) to adjust the glass height
and tighten it.
| •
|
Do not damage
the screws. |
|
|
How To Initialize Motor
Whenever the battery is disconnected, discharged or the
related fuse is replaced or reinstalled, the panoramaroof system must be reset according
to the procedure below.
| 1. |
Turn the ignition key to the
ON position and then close the panoramaroof completely. |
| 2. |
Press and hold the CLOSE button
for more than 10 seconds until the sunroof has moved slightly. |
| 3. |
Release the panoramaroof control
lever. |
| 4. |
Press and hold the CLOSE button
once again until the sunroof performs as follows.
| A. |
Tilt → Slide Open → Slide
Close Then, release the lever.
|
|
| 5. |
Reset procedure of panorama system
is finished. |
When To Initialize The Motor
| 1. |
At the time of manufacture. |
| 2. |
If the Initial setting is erased
due to loss of power. |
| 3. |
After using the manual handle. |
Operating The Panoramaroof Emergency Handle
| 1. |
Use the panoramaroof emergency
handle to close and open the panoramaroof manually for the following case
only.
| A. |
To close the panoramaroof
before driving a vehicle in a rainy day or on the highway if the
panoramaroof can not be closed due to failure of the panoramaroof
motor or controller. |
|
| 2. |
Operating method.
| B. |
Push the emergency handle
up into the hexagonal drive of the panoramaroof motor. You must
push hard enough to disengage the motor clutch; otherwise the emergency
handle will slip due to incomplete fit in the motor. |
| C. |
Carefully turn the emergency
handle clockwise to close the panoramaroof. |
| D. |
After closing the sunroof,
wiggle the handle back and forth as you remove the tool from the
motor, to ensure the motor clutch reengages. |
| E. |
A 5mm hex socket may
be used in place of the emergency handle, with a” Speeder” type
handle. |
| •
|
Do not use power
tools to operate the panoramaroof. |
| •
|
Damaged to the
components may occur. |
|
|
Movable glass Replacement
1.
Open the movable glass fully.
2.
Remove the folding cover (A).
3.
After loosening the mounting
screws, then remove the ...
Replacement
Outside Rear View Mirror Replacement
•
When prying with a flat-tip
screwdriver, wrap it with protect ...
See also:
Rocking the Vehicle
If it is necessary to rock the vehicle to free it from snow, sand, or mud, first
turn the steering wheel right and left to clear the area around your front wheels.
Then, shift back and forth betwe ...
Moving the Front Seat Forward and Backward
To move the seat forward or backward, pull up on the lever under the front edge
of the seat cushion, slide the seat to the desired position, and release the lever.
To ensure the seat is locked i ...
Remote Fuel Filler Lid Release
Depress on the release button located on the driver’s door to open the fuel filler
lid.
WARNING
To avoid injury from sharp objects, it is recommended that protective gloves
be worn when ...
Replacements
Mirror. Repair procedures